Intuition To Do

Last updated: 8/13/12 

 

TV Cabinet 

  • Mount bottom cleat 

  • Sand/finish 

 

Hanging locker, stbd side 

  • Mount blocks w/5200 

  • Cable, lifeline 30"-32" 

 

Dinghy 

  • Seat 

  • Carl 8 hp outboard  

  • Honda 2HP owners manual and tools 

  • Bill Solberg - new painter line 

 

Windless control box shield: 5" - 90 degrees - 16" - 90 degrees - 1"  x 6 1/2 tall (plastic or fibreglass?) 

 

Radar reflector 

  • Purchase another mobri 

 

Engine start switch/electrical -> does it need cleaning? 

  • Possible larger gauge wire from switch to alternator 

  • Where is inline fuse on red line? 

 

Oil leak --> Watch.  Do I need mechanic for consultation? 

  • http://www.samlmorse.com/forum/read.php?5,5827 

 

Bumpers on forward hatch (toilet washers)  

 

Teak 

  • Light sand 320, another coat toerailshatchboards 

 

Setup checklists 

  • Setup/close down 

  • Use of water tanks 

  • Head operations 

    • Use of head: Y-Valve, Seawater Intake, Discharge thruhull 

    • Use of macerator: Y-Valve on "Overboard" -> when to shut off?  (Note, runs about 1 minute to completely empty) 

 

Rust at stanchions 

 

Engine sound insulation 

 

Service winches -  

  • need to remove the 32-2's from cabintop to service.  

  • Why do the handles spin when hauling sheets? 

 

Spinnaker 

  • Harken standup blocks 

 

Wood 1"x3" along aft lockers to hang sheets  

  • Lifeline material? 

  • Low-stretch line? 

  • Wooden dowel 

 

Convert 30' old anchor line to anchor snubber line 

  • Cut loop off 

  • Learn how to make rolling hitch 

 

Fuel system 

  • Add fuel pressure gauge 

 

Diesel 

  • Change water impeller 

  • Adjust valves <- after xxxx hours (verify) 

 

Head/Holding Tank 

  • Mushroom vent 

  • Install replacement pump - Twist N Lock 29040-3000, $89 

  • Add charcoal filter 

  • New o-ring 

 

Port water tank 

  • Clean debris from inside 

 

Cleaning 

  • Port side, heads 

  • Holding tank, fill, empty 

  • Eisenglass 

  • Stern lazerette 

  • Bilge, keelbolts 

  • Canvass/mildew 

  • Check/raise jibs -> verify what we have 

 

Varnish 

  • Toerail, especially by the deck cleats 

  • 6 more coats by port padeye (spinnaker damage) 

 

Fire Extinguishers 

  • Mount fire extinguishers --> outside lazarette??, under sink??? 

  • Refill/test 

 

Electrical 

  • Idle test - leave batteries not charged for several days.  See if boat starts. 

  • Torture test new AGMs. 

  • Test recharge voltage cycle and temperature -> Does temperature monitor switch off? 

  • Alternator 

  • Shore power 

  • Lifeline batteries GPL-27T: my size: 12x6x7, Lifeline AG27 size: 12.01x6.36x8.93, do I have height?  *** Measure ***(http://www.lifelinebatteries.com/marineflyer.php?id=2) 

  • Clean/polish DC ground, replace connectors 

 

Canvas 

  • Repair steering wheel zipper 

  • Mildew -> how to remove? 

  • Teak toerail covers 

  • Dorade covers  

  • Clean handrail, dorado, steering wheel, .... canvas 

 

Fix wood trim 

  • Trim bit more off stbd ceiling trim piece 

 

Lazyjacks 

  • Add 2nd set of lines on port side --> double length, so can pull forward when raise main 

  • Add cleat to port side. 

  • Consider moving cleat back towards cockpit 

 

Wisker Pole 

  • Verify size - is it too small 

  • Add track to mast 

 

Bomar hatch 22" --> replace supporting arm (6" spring 15") 

  • Fix forward hatch "riser arm" - broken/bent spring support (Hood) 

 

Raymarine autohelm 

  • Send autohelm to Raymarine 

 

Drain pvc pipe under mast 

 

Galvanic Isolator - 

  • Test voltages 

 

Wooden plugs on thru-hulls 

 

Leather boots for shrouds/turnbuckles - Boat Leather, 800 466 9110. Speak only with Tom Armantrout